Search Results for ‘actuator’

So I am new here and have been searching the threads and reading tons of issues with the 4x4 on these things. I have the 4x4 light flashing on for .5 and off for 4seconds. I have removed the kebc and 4xr actuators. Both tested good. I took them apart cleaned them and added a little marine...

One primary use for my ATV is to plow when it snows, and I use my winch to lift the plow blade. Works fine, but not great for the end of my winch cable, not to mention the battery draw. I bought a linear actuator to open the chicken coop door, but got one WAY too strong - 1,350 lbs. I was...

Newbie question. The wire harness has broken wires right next to the 4 wheel drive actuator plug. A branch must have cut them. Is it possible to replace just the wire harness? Or do I have to buy a new actuator? Splicing will not work; wires too short. Thanks, rosco

I'm looking for the 4WD differential actuator for a 2003 Prairie 650. OEM part number 16172-1057 or 16172-0039

Hi, I have a 2005 Kawasaki 650 brute force. My 4x4 hasn't been working for over a year. I finally got around to taking a look at this. I've pulled the fuse box and fixed the connectors and I've recently pulled both 4x4 actuator and brake actuator off to look at them. I haven't checked if the...

I have a 2007 Kawasaki prairie 360. The 2wd/4wd light started flashing. It flashes about every 2 seconds. The book said both actuators are bad. I have checked them and they work just fine. Any ideas as to why it is flashing? It won't go into 4wd with it flashing.

Hey everyone would like to start by saying HI since I am new to the sight. I had to purchase a new Front Differential Actuator for my 03 Prairie 650 and while I am waiting on it to arrive I thought I would look up the proper way to re-install it. I have not been able to find anything and I am...

Hi I need to buy a new 4x4 acuator for my 2002 kvf 650 prairie because the one I have now is fubared. I have tried rebuilding it and everything, but no luck. Do you have anything I could possible check out for problems? If not, where can I buy a new one? Preferably for cheap, because I hear that...

Im new to the site and as of yesterday Im new to this Prairie. Issue: * 4wd-2wd light flashing back and forth. * Nothing happens when 4wd/2wd switch is switched from 2wd to 4wd or vise versa. * I hear the actuator for engine braking, and it seems to working when ignition is switched on and off...

Has anyone come across this, or have any ideas? When I turn my key on and the KEBC actuator cycles it makes a fairly loud squeal and grinding noise. When I take it apart, it is clean and no debris in there. It seems to work perfect while riding. It makes the same noise after I turn the quad...

My 05 BF 750 will not rev up no matter what gear. It is like the limiter is kicking in at about 1/4 throttle and then it spits and sputters. Runs and idles fine and can go about 20MPH still. Has a new belt and the the belt sensor was reset. Been told that it may be the actuator on the belt case...

It happens once in a while. The lights will turned from 2 to 4 and jump back and forth. If I shut it off and turn it back on it usually clears out. Its happening more and more so I wanted to get a handle on it. Any suggestions? Thanks so much! New to Brute world. Bikes amazing!